-----------------------------------------
BLAZER MAINTENANCE AND DIAGNOSTIC HISTORY
-----------------------------------------

12/7/02 64600 Driver's side body work
12/15/02 64800 New blower motor, adjust transfer case linkage
1/12/03 64965 oil+filter
1/12/03 64965 new speedo cable
1/19/03 64965 new front hubs
1/19/03 64965 front brakes: napa pads, turn R, new L rotor, repack wheel+spindle bearings
2/23/03 64988 new air filter 
2/23/03 64988 replace transmission rubber lines
3/08/03 65250 replace ground strap
3/11/03 65280 refill front diff 80w90 valvoline duralube synth blend (new gasket)
3/29/05 65300 replace transfer case: NP203 -> NP205
3/30/05 65300 refill rear diff 80w90 valvoline
3/30/05 65300 new alternator + power steering belts, remove AC belt
4/2/03 65300 new front driveshaft, rear lengthened+balanced+new ujoints
4/18/03 66239 transfer case adapter seal replacement (TTS)
4/19/03 66240 transmission filter change
5/04/03 66200 new plugs, wires, distributor cap+rotor
5/18/03 67300 new rear wheel brake cylinders
5/30/03 67332 noticed mis-shifts driving around town, esp left turn?
5/31/03 67332 added 3+ pints ATF. Noticed leak around cooler lines, tightened hose clamps. Drained 1/2 gallon ATF from xfer case. (transfer case seal leaking causing mis-shifts)
6/??/03 -  new transfer case seal again (TTS)
7/2/03 66922 new springs,bushings,ubolts
7/2/03 66922 new fuel filter
7/3/03 67026 new fuel pump
7/4/03 67050 still losing power - fuel pump problem?
7/5/03 67100 replace carburetor: Holley remanufactured carb
7/5/03 67100 new Rancho 9000x shocks
7/5/03 67100 oil+filter 10W30 K+N
7/12/03 68628 warranty carburetor: Holley remanufactured carb
7/??/03 ??    two new steel wheels (white stripe)
9/04/03 71185 oil+filter 10W30 fram
9/9/03 71700 tire r+b
10/03/03 74000 new driver's side exhaust + muffler
10/27/03 74320 new starting battery
10/28/03 74336 replace hood latch mechanism
11/09/03 74838 oil+filter 10W30 fram
12/02/03 76240 add fuel preservative, put on blocks
(storage for 6 months starting 12/03/03, end 06/09/04)
06/09/04 76250 oil+filter 10W30 STP S5, grease zerks
06/09/04 76250 check transfer case, transmission, coolant fluid ok
06/09/04 76250 right rear rancho leaking oil (9112)
06/11/04 76350 warranty right rear rancho 
07/21/04 76500 new washer pump (electronic)
08/??/04 ??    Put on blocks for storage. Added fuel preservative, disconnected battery, removed deep cycle batteries.
03/10/07 ??    Dad checks. Both right tires low (0, 20 psi); front okay. Added 1.5 qt antifreeze. Vehicle started.


-------------------------------
SPECIFICATIONS AND PART NUMBERS
-------------------------------

VIN CKR187Z193700

---original options/specs---
V8-400 1/2ton
TH400 NP203
4265lb stock
31g fuel tank
wheelbase 106.5"
track 71" 
gov loc 3.73 rear
---end orig---

Alternator: Vannata 100amp custom
Automatic Transmission: TH350 
Transfer Case: NP205. 27 spline input, 10 spline front output, 30 spline rear output (80w90)
Rear differential: GM 12-bolt(8 7/8") 3.73 gears  with gov-loc (80w90) 
Front differential: Dana 44 (8 1/2") 3.73 (80w90 valvoline duralube)

BELTS
alternator+fan: Gates XL 7445 (11A1130)
power steering: Gates XL 7360 (11A0915)
air conditioning: Napa premium XL 25-7545 (Gates 7545)

FILTERS AND GASKETS
Air: Wix 42095
Oil Plug Gasket: Felpro #70822 
Oil: Fram mid-grade as per application charts

HOSES
AT cooler 5/16"?
Fuel @ carb 3/8"

SHOCKS
ft Rancho 9118 14.25"-22.125"
rr Rancho 9112 16.125"-26.0"
(These numbers do not match Rancho application charts! They are chosen based on actual suspension travel.)

------------------
STORAGE DIMENSIONS
------------------

Table
bench length 42"
metal to table underside 29"
storage slot: 42x1x28

Sink
edge to wall 1.5-2"

Floor
bench floor: 42Lx22W
rear floor: 33-Lx33.5W

Underbed compartments:
3 @ 3.5 x 17 5/8 x 44+
1 @ 3.5 x 17 7/16 x 44+

Underseat:
pass: 2.5 x 14.25 x 14+
driv: 2.25 x 16.25 x 14+

Cabinets:
doors: 3/4" thick + 1/8" bumper

Water tank:
7 5/8 x 11 3/4 x 29 1/4 (OD)
estimated 11g